 |
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
| Datasheet File OCR Text: |
| MOTOROLA SEMICONDUCTOR TECHNICAL DATA Order this document by 2N6342/D Triacs Silicon Bidirectional Triode Thyristors . . . designed primarily for full-wave ac control applications, such as light dimmers, motor controls, heating controls and power supplies; or wherever full-wave silicon gate controlled solid-state devices are needed. Triac type thyristors switch from a blocking to a conducting state for either polarity of applied anode voltage with positive or negative gate triggering. * Blocking Voltage to 800 Volts * All Diffused and Glass Passivated Junctions for Greater Parameter Uniformity and Stability * Small, Rugged, Thermowatt Construction for Low Thermal Resistance, High Heat Dissipation and Durability * Gate Triggering Guaranteed in Two Modes (2N6342, 2N6343, 2N6344, 2N6345) or Four Modes (2N6346, 2N6347, 2N6348, 2N6349) * For 400 Hz Operation, Consult Factory * 12 Ampere Devices Available as 2N6342A thru 2N6349A 2N6342 thru 2N6349 TRIACs 8 AMPERES RMS 200 thru 800 VOLTS MT1 MT2 G CASE 221A-04 (TO-220AB) STYLE 4 MAXIMUM RATINGS (TJ = 25C unless otherwise noted.) Rating *Peak Repetitive Off-State Voltage(1) (Gate Open, TJ = -40 to +110C) 1/2 Sine Wave 50 to 60 Hz, Gate Open Symbol VDRM 2N6342, 2N6346 2N6343, 2N6347 2N6344, 2N6348 2N6345, 2N6349 (TC = +80C) (TC = +90C) IT(RMS) ITSM 200 400 600 800 8 4 100 Amps Amps Value Unit Volts *RMS On-State Current Full Cycle Sine Wave 50 to 60 Hz *Peak Non-repetitive Surge Current (One Full Cycle, 60 Hz, TC = +80C) Preceded and followed by Rated Current Circuit Fusing (t = 8.3 ms) I2t PGM PG(AV) IGM VGM TJ Tstg 40 20 0.5 2 10 -40 to +125 -40 to +150 A2s Watts Watt Amps Volts C C *Peak Gate Power (TC = +80C, Pulse Width = 2 s) *Average Gate Power (TC = +80C, t = 8.3 ms) *Peak Gate Current *Peak Gate Voltage *Operating Junction Temperature Range *Storage Temperature Range 1. VDRM for all types can be applied on a continuous basis. Blocking voltages shall not be tested with a constant current source such that the voltage ratings of the devices are exceeded. REV 1 Motorola Thyristor Device Data (c) Motorola, Inc. 1995 1 2N6342 thru 2N6349 THERMAL CHARACTERISTICS Characteristic *Thermal Resistance, Junction to Case Symbol RJC Max 2.2 Unit C/W ELECTRICAL CHARACTERISTICS (TC = 25C, and Either Polarity of MT2 to MT1 Voltage, unless otherwise noted.) Characteristic *Peak Blocking Current (VD = Rated VDRM, gate open) TJ = 25C TJ = 100C *Peak On-State Voltage (ITM = 11 A Peak; Pulse Width = 1 to 2 ms, Duty Cycle Gate Trigger Current (Continuous dc) (VD = 12 Vdc, RL = 100 Ohms) (Minimum Gate Pulse Width = 2 s) MT2(+), G(+) All Types MT2(+), G(-) 2N6346 thru 49 MT2(-), G(-) All Types MT2(-), G(+) 2N6346 thru 49 *MT2(+), G(+); MT2(-), G(-) TC = -40C All Types *MT2(+), G(-); MT2(-), G(+) TC = -40C 2N6346 thru 49 Gate Trigger Voltage (Continuous dc) (VD = 12 Vdc, RL = 100 Ohms) (Minimum Gate Pulse Width = 2 s) MT2(+), G(+) All Types MT2(+), G(-) 2N6346 thru 49 MT2(-), G(-) All Types MT2(-), G(+) 2N6346 thru 49 *MT2(+), G(+); MT2(-), G(-) TC = -40C All Types *MT2(+), G(-); MT2(-), G(+) TC = -40C 2N6346 thru 49 (VD = Rated VDRM, RL = 10 k Ohms, TJ = 100C) *MT2(+), G(+); MT2(-), G(-) All Types *MT2(+), G(-); MT2(-), G(-) 2N6346 thru 49 *Holding Current (VD = 12 Vdc, Gate Open) (IT = 200 mA) TC = 25C *TC = -40C tgt Symbol IDRM -- -- -- -- 1.3 10 2 1.55 Min Typ Max Unit A mA Volts mA p 2%) VTM IGT -- -- -- -- -- -- -- VGT 12 12 20 35 -- -- 50 75 50 75 100 125 Volts -- -- -- -- -- -- 0.2 0.2 IH -- -- -- 0.9 0.9 1.1 1.4 -- -- -- -- 6 -- 1.5 2 2.5 2 2.5 2.5 3 -- -- mA 40 75 2 s *Turn-On Time (VD = Rated VDRM, ITM = 11 A, IGT = 120 mA, Rise Time = 0.1 s, Pulse Width = 2 s) Critical Rate of Rise of Commutation Voltage (VD = Rated VDRM, ITM = 11 A, Commutating di/dt = 4.0 A/ms, Gate Unenergized, TC = 80C) *Indicates JEDEC Registered Data. dv/dt(c) -- 5 -- V/s FIGURE 1 - RMS CURRENT DERATING 100 P(AV) , AVERAGE POWER (WATTS) TC , CASE TEMPERATURE ( C) = 30 60 90 92 120 180 84 80 0 1.0 3.0 4.0 5.0 6.0 IT(RMS), RMS ON-STATE CURRENT (AMP) 2.0 7.0 8.0 = CONDUCTION ANGLE dc 10 FIGURE 2 - ON-STATE POWER DISSIPATION dc 6.0 = CONDUCTION ANGLE 60 30 TJ 100C = 180 120 90 96 8.0 88 4.0 [ 2.0 0 0 1.0 2.0 3.0 4.0 5.0 6.0 IT(RMS), RMS ON-STATE CURRENT (AMP) 7.0 8.0 2 Motorola Thyristor Device Data 2N6342 thru 2N6349 FIGURE 3 - TYPICAL GATE TRIGGER VOLTAGE 1.8 Vgt , GATE TRIGGER VOLTAGE (VOLTS) 1.6 1.4 QUADRANT 4 1.2 1.0 0.8 QUADRANTS 0.6 0.4 -60 -40 1 2 3 0 20 40 60 80 100 TJ, JUNCTION TEMPERATURE (C) 120 140 I GT , GATE TRIGGER CURRENT (mA) OFF-STATE VOLTAGE = 12 V 50 OFF-STATE VOLTAGE = 12 V 30 20 1 2 QUADRANT 3 10 4 7.0 5.0 -60 -40 FIGURE 4 - TYPICAL GATE TRIGGER CURRENT -20 -20 0 20 40 60 80 100 TJ, JUNCTION TEMPERATURE (C) 120 140 FIGURE 5 - ON-STATE CHARACTERISTICS 100 70 50 30 20 i TM, INSTANTANEOUS ON-STATE CURRENT (AMP) TJ = 100C 10 7.0 5.0 3.0 2.0 I H , HOLDING CURRENT (mA) 10 7.0 5.0 20 FIGURE 6 - TYPICAL HOLDING CURRENT GATE OPEN MAIN TERMINAL #1 POSITIVE 25C MAIN TERMINAL #2 POSITIVE 3.0 2.0 -60 -40 -20 0 20 40 80 100 60 TJ, JUNCTION TEMPERATURE (C) 120 140 FIGURE 7 - MAXIMUM NON-REPETITIVE SURGE CURRENT 100 ITSM , PEAK SURGE CURRENT (AMP) 1.0 0.7 0.5 0.3 0.2 80 60 CYCLE TJ = 100C f = 60 Hz Surge is preceded and followed by rated current 2.0 3.0 5.0 NUMBER OF CYCLES 7.0 10 40 20 0 1.0 0.1 0.4 1.2 1.6 2.0 2.4 2.8 3.2 3.6 4.0 0.8 vTM, INSTANTANEOUS ON-STATE VOLTAGE (VOLTS) 4.4 Motorola Thyristor Device Data 3 2N6342 thru 2N6349 FIGURE 8 - TYPICAL THERMAL RESPONSE 1.0 r(t), TRANSIENT THERMAL RESISTANCE (NORMALIZED) 0.5 0.2 0.1 0.05 ZJC(t) = r(t) * RJC 0.02 0.01 0.1 0.2 0.5 1.0 2.0 5.0 20 50 t,TIME (ms) 100 200 500 1.0 k 2.0 k 5.0 k 10 k 4 Motorola Thyristor Device Data 2N6342 thru 2N6349 PACKAGE DIMENSIONS -T- B F C SEATING PLANE T S NOTES: 1. DIMENSIONING AND TOLERANCING PER ANSI Y14.5M, 1982. 2. CONTROLLING DIMENSION: INCH. 3. DIMENSION Z DEFINES A ZONE WHERE ALL BODY AND LEAD IRREGULARITIES ARE ALLOWED. DIM A B C D F G H J K L N Q R S T U V Z INCHES MIN MAX 0.570 0.620 0.380 0.405 0.160 0.190 0.025 0.035 0.142 0.147 0.095 0.105 0.110 0.155 0.014 0.022 0.500 0.562 0.045 0.055 0.190 0.210 0.100 0.120 0.080 0.110 0.045 0.055 0.235 0.255 0.000 0.050 0.045 --- --- 0.080 MILLIMETERS MIN MAX 14.48 15.75 9.66 10.28 4.07 4.82 0.64 0.88 3.61 3.73 2.42 2.66 2.80 3.93 0.36 0.55 12.70 14.27 1.15 1.39 4.83 5.33 2.54 3.04 2.04 2.79 1.15 1.39 5.97 6.47 0.00 1.27 1.15 --- --- 2.04 4 Q 123 A U K H Z L V G D N J R STYLE 4: PIN 1. 2. 3. 4. MAIN TERMINAL 1 MAIN TERMINAL 2 GATE MAIN TERMINAL 2 CASE 221A-04 (TO-220AB) Motorola Thyristor Device Data 5 2N6342 thru 2N6349 Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and specifically disclaims any and all liability, including without limitation consequential or incidental damages. "Typical" parameters can and do vary in different applications. All operating parameters, including "Typicals" must be validated for each customer application by customer's technical experts. Motorola does not convey any license under its patent rights nor the rights of others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal Opportunity/Affirmative Action Employer. Literature Distribution Centers: USA: Motorola Literature Distribution; P.O. Box 20912; Phoenix, Arizona 85036. EUROPE: Motorola Ltd.; European Literature Centre; 88 Tanners Drive, Blakelands, Milton Keynes, MK14 5BP, England. JAPAN: Nippon Motorola Ltd.; 4-32-1, Nishi-Gotanda, Shinagawa-ku, Tokyo 141, Japan. ASIA PACIFIC: Motorola Semiconductors H.K. Ltd.; Silicon Harbour Center, No. 2 Dai King Street, Tai Po Industrial Estate, Tai Po, N.T., Hong Kong. 6 *2N6342/D* Motorola Thyristor Device Data 2N6342/D This datasheet has been download from: www..com Datasheets for electronics components. |
Price & Availability of 2N6346
 |
|
|
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
| [Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
|
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |